TM-32-5811-024-14-P

• OPERATOR, ORGANIZATIONAL, DIRECT SUPPORT, GENERAL SUPPORT AND DEPOT MAINTENANCE MANUAL
• WARNING
• OPERATOR, ORGANIZATIONAL, DIRECT SUPPORT, GENERAL SUPPORT AND DEPOT MAINTENANCE MANUAL
• OPERATOR, ORGANIZATIONAL, DIRECT SUPPORT, GENERAL SUPPORT AND DEPOT MAINTENANCE MANUAL
• OPERATOR, ORGANIZATIONAL, DIRECT SUPPORT, GENERAL SUPPORT AND DEPOT MAINTENANCE MANUAL
• LIST OF EFFECTIVE PAGES
• RECORD OF CHANGES
• TABLE OF CONTENTS
• TABLE OF CONTENTS
• TABLE OF CONTENTS
• LIST OF ILLUSTRATIONS
• LIST OF TABLES
• CHAPTER 1 INTRODUCTION
• Figure 1-1. Digital Processor Test Set AN/USM-433
• Table 1-1. Digital Processor Test Set Power and Signal Connections
• Table 1-1. Digital Processor Test Set Power and Signal Connections - Continued
• Table 1-1. Digital Processor Test Set Power and Signal Connections - Continued
• Table 1-1. Digital Processor Test Set Power and Signal Connections - Continued
• Table 1-1. Digital Processor Test Set Power and Signal Connections - Continued
• Table 1-1. Digital Processor Test Set Power and Signal Connections - Continued
• Table 1-1. Digital Processor Test Set Power and Signal Connections - Continued
• Table 1-1. Digital Processor Test Set Power and Signal Connections - Continued
• Table 1-1. Digital Processor Test Set Power and Signal Connections - Continued
• Table 1-1. Digital Processor Test Set Power and Signal Connections - Continued
• Tabulated data.
• CHAPTER 2 SERVICE UPON RECEIPT AND INSTALLATION
• Figure 2-1. Typical Communication Processor Test Configuration
• Figure 2-2. DF Test Configuration
• Figure 2-3. Typical Communication Processor Control-Indicator Test Configuration
• Figure 2-4. Typical Communication Processor Transceiver I/O Test Configuration (Module A30)
• Table 2-1. Communication Processor Test Configuration Cables
• Table 2-2. DF Test Configuration Cables
• Table 2-3. Communication Processor Control-Indicator Test Cables
• Figure 3-1. Digital Processor Test Set Controls, Indicators, and Connectors
• Table 3-1. Digital Processor Test Set Controls, Indicators, and Connectors
• Table 3-1. Digital Processor Test Set Controls, Indicators, and Connectors - Continued
• Table 3-1. Digital Processor Test Set Controls, Indicators, and Connectors - Continued
• Table 3-1. Digital Processor Test Set Controls, Indicators, and Connectors - Continued
• Table 3-1. Digital Processor Test Set Controls, Indicators, and Connectors - Continued
• Table 3-1. Digital Processor Test Set Controls, Indicators, and Connectors - Continued
• Section II. OPERATION UNDER USUAL CONDITIONS
• CHAPTER 4 ORGANIZATIONAL MAINTENANCE INSTRUCTIONS
• Table 4-1. Daily Preventive Maintenance Checks and Services
• Table 4-2. Weekly Preventive Maintenance Checks and Services
• Section IV. TROUBLESHOOTING
• CHAPTER 5 FUNCTIONING OF EQUIPMENT
• Power Supply Assembly and Distribution.
• Table 5-1. Card Cage Assembly CCA Functions
• Table 5-1. Card Cage Assembly CCA Functions - Continued
• Section III. DETAILED THEORY OF OPERATION
• Digital Processor Test Set CPU Control Function.
• Figure 5-1. Multiplexed Data Word Select Timing Diagram
• Table 5-2. Input Display Data Word
• Table 5-3. Typical Digital Processor Control Sequence
• RF Processor Simulation Function.
• Figure 5-2. Servo Loop Test Functional Block Diagram
• Servo Loop Test
• Figure 5-3. Digital-to-Analog Conversion
• Serial Interface Test Function.
• Figure 5-5. Self-Test Functional Block Diagram
• Serial Interface Test Function.
• Figure 5-6. Serial Interface Test Timing Diagram
• Communication Processor Control-Indicator Interface Test Function
• Table 5-4. Test Status/CMD Word
• Figure 5-7. Communications Processor Control-Indicator Interface Test Timing Diagram
• Communication Processor Control-Indicator Interface Test Function.
• Control-Indicator Test Function.
• Figure 5-8. Control Indicator Test Timing Diagram
• Detailed Description
• Communication Processor Transceiver I/O Module Test.
• Figure 5-9. Transceiver Test CCA A10 PR Code Generator Functional Block Diagram
• 10-Hz Oscillator
• CHAPTER 6 INTERMEDIATE SUPPORT MAINTENANCE INSTRUCTIONS
• Section III. TROUBLESHOOTING
• Table 6-1. Digital Processor Test Set Troubleshooting Steering Chart
• Troubleshooting Procedures.
• Section IV. MAINTENANCE OF THE DIGITAL PROCESSOR TEST SET
• Disassembly/Assembly Procedures.
• Section V. INTERMEDIATE SUPPORT TEST PROCEDURES
• Test Procedures
• CHAPTER 7 INTEGRATED CIRCUIT DATA
• CHAPTER 7 INTEGRATED CIRCUIT DATA
• DM54L165A Low-Power Parallel-In Serial-Out 8-Bit Shift Register
• DM7160 6-Bit Comparator
• DM7551 Tri-State Quad D Flip-Flop
• DM76L76 Low-Power Presettable Binary Counter
• DM7820A Dual Line Receiver
• DM7830 Dual Differential Line Receiver
• LH0002 Current Amplifier
• LM111 Voltage Comparator
• LM124 Quad Operational Amplifier
• MC4324 Dual Voltage-Controlled Multivibrator
• MN3001 8-Bit D/A Converter
• SE556 Dual Timer
• SNC54LS112 Dual J-K with Clear and Preset
• SNC54LS174 Hex/Quad D-Type Flip-Flop with Clear
• SNC54LS253 Dual 4-Line-to-l-Line Data Selector/Multiplexer with 3-State Output
• SNC54LS257 Quad 2-Line-to-1-Line Data Selector/Multiplexer
• SNC54LS295A 4-Bit Cascadable Shift Register with 3-State Output
• SNC54LS86 Quad 2-Input Exclusive-OR Gate
• SNC54L157 Quad 2-Line-to-1-Line Data Selector/Multiplexer
• SNC54S260 Dual 5-Input Positive-NOR Gate
• SNC54120 Dual Pulse Synchronizer/Driver
• S54165 Parallel-Load 8-Bit Shift Register
• 93L16D Low-Power 4-Bit Binary Counter
• CHAPTER 8 INTERCONNECT WIRING LIST
• Wire List
• Wire List
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• Wire List-cont.
• DIGITAL PROCESSOR TEST CABLE W201
• DIGITAL PROCESSOR TEST CABLE W211
• DIGITAL PROCESSOR TEST CABLE W212
• DIGITAL PROCESSOR TEST CABLE W213
• DIGITAL PROCESSOR TEST CABLE W216
• DIGITAL PROCESSOR TEST CABLE W217
• DIGITAL PROCESSOR TEST CABLE W218
• DIGITAL PROCESSOR TEST CABLE W236
• DIGITAL PROCESSOR TEST CABLE W236-cont.
• DIGITAL PROCESSOR TEST CABLE W237
• DIGITAL PROCESSOR TEST CABLE W239
• DIGITAL PROCESSOR TEST CABLE W240
• APPENDIX A REFERENCES
• Supply Bulletins.
• Army Regulations.
• APPENDIX B MAINTENANCE ALLOCATION CHART
• Explanation of Format
• Explanation of Format-cont.
• MAINTENANCE ALLOCATION CHART FOR DIGITAL PROCESSOR SET AN/USM-433
• MAINTENANCE ALLOCATION CHART FOR DIGITAL PROCESSOR SET AN/USM-433
• MAINTENANCE ALLOCATION CHART FOR DIGITAL PROCESSOR SET AN/USM-433
• MAINTENANCE ALLOCATION CHART FOR DIGITAL PROCESSOR SET AN/USM-433
• MAINTENANCE ALLOCATION CHART FOR DIGITAL PROCESSOR SET AN/USM-433
• MAINTENANCE ALLOCATION CHART FOR DIGITAL PROCESSOR SET AN/USM-433
• MAINTENANCE ALLOCATION CHART FOR DIGITAL PROCESSOR SET AN/USM-433-cont.
• MAINTENANCE ALLOCATION CHART FOR DIGITAL PROCESSOR SET AN/USM-433-cont.
• MAINTENANCE ALLOCATION CHART FOR DIGITAL PROCESSOR SET AN/USM-433-cont.
• DIGITAL PROCESSOR TEST SET AN/USM-433
• APPENDIX C BASIC ISSUE ITEMS LIST, ITEMS TROOP INSTALLED OR AUTHORIZED LIST, AND REPAIR PARTS AND SPECIAL TOOLS LIST
• TABLE OF CONTENTS
• TABLE OF CONTENTS-Continued
• Section I. INTRODUCTION
• Explanation of Columns
• Maintenance Code
• Maintenance Code-cont.
• National Stock Number
• Special Information
• How to Locate Repair Parts.
• Abbreviations
• Section II. BASIC ISSUE ITEMS LIST
• Section III. ITEMS TROOP INSTALLED OR AUTHORIZED LIST
• Section III. ITEMS TROOP INSTALLED OR AUTHORIZED LIST-cont.
• Section III. ITEMS TROOP INSTALLED OR AUTHORIZED LIST-cont.
• Section III. ITEMS TROOP INSTALLED OR AUTHORIZED LIST-cont.
• Figure C-1. Digital Processor Test Set AN/USM-433 (Sheet 1 of 5)
• Figure C-1. Digital Processor Test Set AN/USM-433 (Sheet 2 of 5)
• Figure C-1. Digital Processor Test Set AN/USM-433 (Sheet 3 of 5)
• Figure C-1. Digital Processor Test Set AN/USM-433 (Sheet 4 of 5)
• Figure C-1. Digital Processor Test Set AN/USM-433 (Sheet 5 of 5)
• REPAIR PARTS LIST
• Figure C-2. Processor Display CCA A1 (Sheet 1 of 2)
• Figure C-2. Processor Display CCA A1 (Sheet 2 of 2)
• REPAIR PARTS LIST
• Figure C-3. Electrical Plug Connector A1P1, A2P1, A3P1, A4P1, A5P1, A6P1, A7P1, A8P1, A9P1, A10P1, or A11P1
• REPAIR PARTS LIST
• Figure C-4. AGE Display CCA A2 (Sheet 1 of 2)
• REPAIR PARTS LIST
• REPAIR PARTS LIST
• Figure C-5. Display Storage CCA A3 (Sheet 1 of 2)
• Figure C-5. Display Storage CCA A3 (Sheet 2 of 2)
• REPAIR PARTS LIST
• Figure C-6. Display Storage Capacitor A3A1
• REPAIR PARTS LIST
• Figure C-7. Display Storage Resistor A3A2
• REPAIR PARTS LIST
• Figure C-8. Diagnostic Buffer CCA A4 (Sheet 1 of 2)
• Figure C-8. Diagnostic Buffer CCA A4 (Sheet 2 of 2)
• REPAIR PARTS LIST
• Figure C-9. RF Processor Simulator CCA A5 (Sheet 1 of 2)
• Figure C-9. RF Processor Simulator CCA A5 (Sheet 2 of 2)
• REPAIR PARTS LIST
• REPAIR PARTS LIST
• Figure C-10. Serial Interface Test CCA A6 (Sheet 1 of 2)
• Figure C-10. Serial Interface Test CCA A6 (Sheet 2 of 2)
• REPAIR PARTS LIST
• Figure C-11. Logic Control CCA A7 (Sheet 1 of 2)
• Figure C-11. Logic Control CCA A7 (Sheet 2 of 2)
• REPAIR PARTS LIST
• Figure C-12. Lamp Driver CCA A8 (Sheet 1 of 2)
• Figure C-12. Lamp Driver CCA A8 (Sheet 2 of 2)
• REPAIR PARTS LIST
• REPAIR PARTS LIST
• Figure C-13. Control Indicator Test CCA A9 (Sheet 1 of 2)
• Figure C-13. Control Indicator Test CCA A9 (Sheet 2 of 2)
• REPAIR PARTS LIST
• REPAIR PARTS LIST
• Figure C-14. Transceiver Test CCA A10 (Sheet 1 of 2)
• Figure C-14. Transceiver Test CCA A10 (Sheet 2 of 2)
• REPAIR PARTS LIST
• Figure C-15. Read Only Memory CCA A11 (Sheet 1 of 3)
• Figure C-15. Read Only Memory CCA A11 (Sheet 2 of 3)
• Figure C-15. Read Only Memory CCA A11 (Sheet 3 of 3)
• REPAIR PARTS LIST
• Figure C-16. Card Cage Assembly A19
• REPAIR PARTS LIST
• Figure C-17. Power Supply A19
• REPAIR PARTS LIST
• Figure C-18. Electrical Plug Connector P1, P2, P3, or W1P1.
• REPAIR PARTS LIST
• Figure C-19. Special Purpose Cable Assembly W1.
• REPAIR PARTS LIST
• REPAIR PARTS LIST
• Figure C-20. Digital Processor Test Set Cable Kit Configuration I.
• Figure C-20. Digital Processor Test Set Cable Kit Configuration I.
• REPAIR PARTS LIST
• Figure C-21. Special Purpose Cable Assembly W201
• REPAIR PARTS LIST
• Figure C-22. Special Purpose Cable Assembly W202
• REPAIR PARTS LIST
• Figure C-23. Special Purpose Cable Assembly W203
• REPAIR PARTS LIST
• Figure C-24. Special Purpose Cable Assembly W204
• REPAIR PARTS LIST
• Figure C-25. RF Cable Assembly W205 or W243
• REPAIR PARTS LIST
• Figure C-26. RF Cable Assembly W206
• REPAIR PARTS LIST
• Figure C-27. RF Cable Assembly W207
• REPAIR PARTS LIST
• Figure C-28. Special Purpose Cable Assembly W208
• REPAIR PARTS LIST
• Figure C-29. Special Purpose Cable Assembly W209
• REPAIR PARTS LIST
• Figure C-30. Special Purpose Cable Assembly W210
• REPAIR PARTS LIST
• Figure C-31. Special Purpose Cable Assembly W211
• REPAIR PARTS LIST
• Figure C-32. Special Purpose Cable Assembly W212
• REPAIR PARTS LIST
• Figure C-33. Special Purpose Cable Assembly W213
• REPAIR PARTS LIST
• Figure C-34. Special Purpose Cable Assembly W214
• REPAIR PARTS LIST
• Figure C-35. Special Purpose Cable Assembly W215
• REPAIR PARTS LIST
• Figure C-36. Special Purpose Cable Assembly W216
• REPAIR PARTS LIST
• Figure C-37. Special Purpose Cable Assembly W217
• REPAIR PARTS LIST
• Figure C-38. RF Cable Assembly W238
• REPAIR PARTS LIST
• Figure C-38A. Jumper Plug W239
• REPAIR PARTS LIST
• Figure C-38B. Jumper Plug W240
• REPAIR PARTS LIST
• Figure C-39. Special Purpose Cable Assembly W232, W242, W244
• REPAIR PARTS LIST
• Figure C-40. Digital Processor Test Set Cable Kit Configuration II
• Figure C-40. Digital Processor Test Set Cable Kit Configuration II
• REPAIR PARTS LIST
• Figure C-41. Special Purpose Cable Assembly W218
• REPAIR PARTS LIST
• Figure C-42. Special Purpose Cable Assembly W219
• REPAIR PARTS LIST
• Figure C-43. Special Purpose Cable Assembly W220
• REPAIR PARTS LIST
• Figure C-44. Special Purpose Cable Assembly W221
• REPAIR PARTS LIST
• Figure C-45. Special Purpose Cable Assembly W222
• REPAIR PARTS LIST
• Figure C-46. Special Purpose Cable Assembly W223
• REPAIR PARTS LIST
• Figure C-47. RF Cable Assembly W224, W225, W226, or W227
• REPAIR PARTS LIST
• Figure C-48. Digital Processor Test Set Cable Kit Configuration III
• Figure C-48. Digital Processor Test Set Cable Kit Configuration III
• REPAIR PARTS LIST
• Figure C-49. Special Purpose Cable Assembly W228
• REPAIR PARTS LIST
• Figure C-50. Special Purpose Cable Assembly W229
• REPAIR PARTS LIST
• Figure C-51. Special Purpose Cable Assembly W237
• REPAIR PARTS LIST
• Figure C-52. Digital Processor Test Set Cable Kit Configuration IV Sheet 1 of 2)
• Figure C-52. Digital Processor Test Set Cable Kit Configuration IV (Sheet 2 of 2)
• REPAIR PARTS LIST
• Figure C-53. RF Cable Assembly W230 or W231
• REPAIR PARTS LIST
• Figure C-54. RF Cable Assembly W233 or W234
• REPAIR PARTS LIST
• Figure C-55. RF Cable Assembly W235 or W241
• REPAIR PARTS LIST
• Figure C-56. Special Purpose Cable Assembly W236
• Section V. SPECIAL TOOLS LIST
• Section VI. NATIONAL STOCK NUMBER AND PORT NUMBER INDEX
• Section VI. NATIONAL STOCK NUMBER AND PORT NUMBER INDEX
• Section VI. NATIONAL STOCK NUMBER AND PORT NUMBER INDEX
• Section VI. NATIONAL STOCK NUMBER AND PORT NUMBER INDEX
• Section VI. NATIONAL STOCK NUMBER AND PORT NUMBER INDEX
• PART NUMBER TO FIGURE AND ITEM NUMEER INDEX
• PART NUMBER TO FIGURE AND ITEM NUMEER INDEX
• PART NUMBER TO FIGURE AND ITEM NUMEER INDEX
• PART NUMBER TO FIGURE AND ITEM NUMEER INDEX
• PART NUMBER TO FIGURE AND ITEM NUMEER INDEX
• INDEX
• INDEX-cont.
• INDEX-cont.
• INDEX-cont.
• INDEX-cont.
• Figure FO-1. Digital Processor Test Set Block Diagram
• Figure FO-2. Power Supply and Distribution Diagram
• Figure FO-3. Digital Processor Test Set Control Functional Block Diagram
• Figure FO-4. Serial Interface Test CCA A6 Functional Block Diagram
• Figure FO-5. Communication Processor Control-Indicator
• Figure FO-6. Digital Processor
• Figure FO-7. Processor Display CCA A1Schematic Diagram
• Figure FO-8. AGE Display CCA A2 Schematic Diagram (Sheet 1 of 2)
• Figure FO-8. AGE Display CCA A2 Schematic Diagram (Sheet 2 of 2)
• Figure FO-9. Display Storage CCA A3 Schematic Diagram (Sheet 1 of 2)
• Figure FO-9. Display Storage CCA A3 Schematic Diagram (Sheet 2 of 2)
• Figure FO-10. Diagnostic Buffer CCA A4 Schematic Diagram (Sheet 1 of 2)
• Figure FO-10. Diagnostic Buffer CCA A4 Schematic Diagram (Sheet 2 of 2)
• Figure FO-11. RF Processor Simulator CCA A5 Schematic Diagram (Sheet 1 of 2)
• Figure FO-11. RF Processor Simulator CCA A5 Schematic Diagram (Sheet 2 of 2)
• Figure FO-12. Serial Interface Test CCA A6 Schematic Diagram (Sheet 1 of 2)
• Figure FO-12. Serial Interface Test CCA A6 Schematic Diagram (Sheet 2 of 2)
• Figure FO-13. Logic Control CCA A7 Schematic Diagram (Sheet 1 of 2)
• Figure FO-13. Logic Control CCA A7 Schematic Diagram (Sheet 1 of 2)
• Figure FO-14. Lamp Driver CCA A8 Schematic Diagram
• Figure FO-15. Control-Indicator Test CCA A9 Schematic Diagram (Sheet 1 of 3)
• Figure FO-15. Control-Indicator Test CCA A9 Schematic Diagram (Sheet 2 of 3)
• Figure FO-15. Control-Indicator Test CCA A9 Schematic Diagram (Sheet 2 of 3)
• Figure FO-16. Transceiver Test CCA A10 Schematic Diagram (Sheet 1 of 2)
• Figure FO-16. Transceiver Test CCA A10 Schematic Diagram (Sheet 1 of 2)
• Figure FO-17. Diagnostic ROM CCA A11, A12 Schematic Diagram
• Figure FO-18. Power Supply Fault Isolation Flowchart (Sheet 1 of 2)
• Figure FO-18. Power Supply Fault Isolation Flowchart (Sheet 2 of 2)
• Figure FO-19. CPU Display Fault Isolation Flowchart
• Figure FO-20. Serial Interface Test Functional Fault Isolation Flowchart
• Figure FO-21. RF Processor Simulator Fault Isolation Flowchart
• Figure FO-22. CPU Control and Address Display Fault Isolation Flowchart (Sheet 1 of 2)
• Figure FO-22. CPU Control and Address Display Fault Isolation Flowchart (Sheet 1 of 2)
• Figure FO-23. Transceiver I/O Test Function Fault Isolation Flowchart
• Figure FO-24. Communication Processor Control-Indicator and Interface Test Fault Isolation Flowchart (Sheet 1 of 3)
• Figure FO-24. Communication Processor Control-Indicator and Interface Test Fault Isolation Flowchart (Sheet 2 of 3)
• Figure FO-24. Communication Processor Control-Indicator and Interface Test Fault Isolation Flowchart (Sheet 3 of 3)
• Figure FO-25. Digital Processor Test Set Wiring Diagram
• The Metric System and Equivalents
• TM-32-5811-024-14-P
• DISTRIBUTION
• RECOMMENDED CHANGES TO EQUIPMENT TECHNICAL PUBLICATIONS
• BLANK PAGE

Privacy Statement - Press Release - Copyright Information. - Contact Us