TM-5-4930-233-14

• OPERATOR, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL
• OPERATOR, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL
• OPERATOR, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL
• WARNING
• WARNING
• WARNING
• TABLE OF CONTENTS
• TABLE OF CONTENTS (CONT)
• TABLE OF CONTENTS (CONT)
• TABLE OF CONTENTS (CONT)
• TABLE OF CONTENTS (CONT)
• CHAPTER 1 INTRODUCTION
• Section II. EQUIPMENT DESCRIPTION
• LOCATION AND DESCRIPTION OF MAJOR COMPONENTS
• EQUIPMENT DATA
• Section III. TECHNICAL PRINCIPLES OF OPERATIONS
• MAJOR ASSEMBLIES
• TRAILER
• TRAILER
• CHAPTER 2 OPERATING INSTRUCTIONS
• Table 2-1. OPERATOR'S CONTROLS
• Table 2-1. OPERATOR'S CONTROLS - CONTINUED
• Table 2-1. OPERATOR'S CONTROLS - CONTINUED
• Table 2-1. OPERATOR'S CONTROLS - CONTINUED
• Table 2-1. OPERATOR'S CONTROLS - CONTINUED
• Section II. OPERATOR'S PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS)
• Leakage Definitions for Unit PMCS
• Table 2-2. Preventive Maintenance Checks and Services
• Table 2-2. Preventive Maintenance Checks and Services - (Continued)
• Table 4-2. Preventive Maintenance Checks and Services - (Continued)
• Section III. OPERATION UNDER USUAL CONDITIONS
• Engine Stopping
• Filling Lube Tank
• Always keep lubricant containers three-quarters full.
• Preparing Lubricant Pumps For Operation.
• The following steps 6 thru 9 apply to any of four dispensers.
• Dispensing General Purpose Grease
• Dispensing Gear Oil
• Dispensing Engine Oil
• Use of Air Chuck
• OPERATION OF AUXILIARY EQUIPMENT
• OPERATION OF AUXILIARY EQUIPMENT (CONT)
• OPERATION OF AUXILIARY EQUIPMENT (CONT)
• Oil Spray Gun
• PREPARATION FOR MOVEMENT
• PREPARATION FOR MOVEMENT
• PREPARATION FOR MOVEMENT
• Driving
• After towing
• After towing (CONT)
• OPERATION AND SAFETY INSTRUCTION PLATES
• HETER OPERATION
• Section IV. OPERATION UNDER UNUSUAL CONDITIONS
• OPERATION IN EXTREME COLD
• Operation of Winterization Assembly.
• OPERATION IN EXTREME HEAT.
• FORDING.
• CHAPTER 3 OPERATOR'S MAINTENANCE INSTRUCTIONS
• Trailer Assembly
• Section II. OPERATOR TROUBLESHOOTING
• Table 3-1. Operator's Troubleshooting
• Table 3-1. Operator's Troubleshooting - Continued
• Table 3-1. Operator's Troubleshooting - Continued
• Table 3-1. Operator's Troubleshooting - Continued
• Table 3-1. Operator's Troubleshooting - Continued
• Table 3-1. Operator's Troubleshooting - Continued
• Section III. OPERATOR MAINTENANCE PROCEDURES
• ALCOHOL INJECTOR - SERVICE
• WHEEL AND TIRE - SERVICE
• CHAPTER 4 UNIT MAINTENANCE INSTRUCTIONS
• PRELIMINARY SERVICING AND ADJUSTMENT OF EQUIPMENT
• GENERAL
• PREVENTIVE MAINTENANCE CHECKS AND SERVICE (PMCS) TABLE
• Table 4-1. Unit PMCS
• Table 4-1. Unit PMCS - Continued
• Section IV. UNIT TROUBLESHOOTING
• Table 4-2. Unit Troubleshooting
• Table 4-2. Unit Troubleshooting - Continued
• Table 4-2. Unit Troubleshooting - Continued
• Table 4-2. Unit Troubleshooting - Continued
• Table 4-2. Unit Troubleshooting - Continued
• Table 4-2. Unit Troubleshooting - Continued
• Section V. UNIT MAINTENANCE INSTRUCTIONS
• GENERAL WIRING REPAIR
• ENCLOSURE - REPLACE
• Installation
• DOORS - REPLACE
• DOORS- REPLACE - (Cont.)
• PANEL - REPAIRS
• PANELS - REPLACE
• AIR FILTER-REPLACE/SERVICE
• FUEL CAP AND FILLER NECK ASSEMBLY - REPLACE/REPAIR
• Assembly
• Installation
• FUEL CAP AND FILLER NECK ASSEMBLY - REPLACE/REPAIR - (Cont.)
• TOOL BOX ASSEMBLY - REPLACE/REPAIR
• Disassembly
• Installation
• FUEL TANK - SERVICE/REPLACE
• Cleaning
• Removal
• FUEL TANK ASSEMBLY - REPAIR
• IMAGE
• Repair
• IMAGE
• REEL CABINET ASSEMBLY - REPAIR
• Repair
• Installation
• Installation
• BATTERY BOX ASSEMBLY - SERVICE/REPLACE/REPAIR
• BATTERY BOX ASSEMBLY - SERVICE/REPLACE/REPAIR - (Cont.)
• BATTERY BOX ASSEMBLY - SERVICE/REPLACE/REPAIR - (Cont.)
• Removal
• BATTERY BOX ASSEMBLY - SERVICE/REPLACE/REPAIR - (Cont.)
• Disassembly
• Repair
• Assembly
• Installation
• Installation - (cont.)
• Installation - (cont.)
• GEAR LUBE AND ENGINE OIL DISPENSERS - REPLACE
• IMAGE
• AIR, LUBE AND GREASE HOSES - REPLACE
• IMAGE
• AIR, LUBE AND GREASE HOSES - REPAIR
• REEL ASSEMBLY - REPLACE/REPAIR
• Disassembly
• Repair
• Assembly
• Installation
• BELTS - REPLACE/ADJUST
• Removal
• Removal (cont)
• Installation
• Installation (CONT)
• Adjustment
• Adjustment (CONT)
• STARTER - TEST/REPLACE
• Removal
• ALTERNATOR - TEST/REPLACE
• Removal
• WIRING HARNESS - TEST/REPLACE/REPAIR
• Table 4-3. Wire List
• CONTROL PANEL- TEST/REPLACE/REPAIR
• CONTROL PANEL - TEST/REPLACE/REPAIR - (Cont.)
• Removal
• Removal (CONT)
• Disassembly
• Assembly
• Installation
• Installation (CONT)
• PILOT VALVE - ADJUST/REPLACE
• Removal
• PRESSURE RELIEF VALVE - REPLACE
• AIR COMPRESSOR - REPLACE
• Removal
• Installation
• ENGINE - REPLACE
• Removal
• Removal - (cont.)
• Removal - (cont.)
• Installation
• Installation (CONT)
• Installation - (cont.)
• Installation - (cont.)
• AIR RECEIVER TANK - REPLACE
• AIR RECEIVER TANK - REPLACE - (Cont.)
• AIR COMPRESSOR HOSE, LINES AND FITTINGS - REPLACE
• IMAGE
• Installation
• ENGINE OIL EXTENSION ASSEMBLY - REPLACE
• ENGINE EXHAUST SYSTEM - REPLACE
• Installation
• ALCOHOL INJECTOR - ADJUST/REPLACE/REPAIR
• Removal
• Disassembly
• Assembly
• Installation
• AIR REGULATOR - REPLACE
• Removal
• LOW AND HIGH PRESSURE PUMPS - REPLACE
• Installation
• LUBE TANK - REPLACE/REPAIR
• Removal
• Disassembly
• Repair
• Assembly
• Installation
• HEATER - REPLACE
• Removal
• Removal - (cont.)
• Installation
• Installation (CONT)
• CONTROL BOX- TEST/REPLACE
• Removal
• FUEL PUMP - TEST/REPLACE
• Removal
• WIRING HARNESS - TEST/REPLACE/REPAIR
• WIRING DIAGRAM
• DUCTS, HEATER HOSES AND EXHAUST SYSTEM
• IMAGE
• LUBE PIPING - REPLACE/REPAIR
• Removal
• Repair
• IMAGE
• PNEUMATIC PIPING - REPLACE/REPAIR
• Removal
• Repair
• Installation
• TRAILER COMPONENTS
• Removal
• Installation
• Installation (CONT)
• COUPLER (GLAD HAND) - REPLACE/REPAIR
• Repair
• EMERGENCY RELAY VALVE - REPLACE
• EMERGENCY RELAY VALVE - REPLACE
• AIR SUPPLY VALVE - REPLACE
• Installation
• AIR CLEANER ASSEMBLY - REPLACE/REPAIR
• Disassembly
• Repair
• Installation
• BRAKE LINES AND HOSES - REPLACE
• IMAGE
• Installation
• AIR TANK - REPLACE
• JUNCTION BOX - TEST/REPLACE
• Test
• Removal
• Table 4-6. Power Output Chart
• CLEARANCE LIGHT - TEST/REPLACE
• Removal.
• STOP AND TURN LIGHT - TEST/REPLACE
• Removal
• WIRING HARNESS - TEST/REPLACE/REPAIR
• Table 4-7. WIRE LIST
• Repair
• WHEEL AND TIRE ASSEMBLY - TEST/REPLACE/REPAIR
• Removal
• Repair
• Installation
• BRAKE ASSEMBLY - INSPECT/ADJUST/BLEED/REPLACE/REPAIR
• Adjustment
• Bleeding
• Removal
• Removal (CONT)
• Disassembly
• Repair
• Assembly
• Installation
• Installation - (cont.)
• JACK LEG ASSEMBLY - REPLACE
• Installation
• Section VI. PREPARATION FOR STORAGE OR SHIPMENT
• IMAGE
• PACKING, SHIPMENT AND STORAGE
• Storage
• INSPECTION IN ADMINISTRATIVE STORAGE
• CHAPTER 5 DIRECT SUPPORT MAINTENANCE INSTRUCTIONS
• Table 5-1. Direct Support Troubleshooting
• Table 5-1. Direct Support Troubleshooting
• Table 5-1. Direct Support Troubleshooting - Continued
• Table 5-1. Direct Support Troubleshooting - Continued
• Table 5-1. Direct Support Troubleshooting - Continued
• Table 5-1. Direct Support Troubleshooting - Continued
• Table 5-1. Direct Support Troubleshooting - Continued
• Section II. MAINTENANCE PROCEDURES
• IMAGE
• DOORS - REPAIR
• Repair
• PANELS- REPLACE
• Installation
• TRANSFER PUMP - REPAIR/ADJUST
• Disassembly
• Disassembly - (cont.)
• Disassembly - (cont.)
• Disassembly - (cont.)
• Repair
• Assembly
• Assembly - (cont.)
• Adjustment
• Adjustment
• Installation
• FUEL TANK ASSEMBLY - REPAIR
• IMAGE
• Repair
• IMAGE
• GEAR LUBE DISPENSER - REPAIR
• Disassembly
• Disassembly - (cont.)
• Disassembly - (cont.)
• Repair
• Assembly
• Assembly
• Assembly - (cont.)
• ENGINE OIL DISPENSER - REPAIR
• IMAGE
• Disassembly - (cont.)
• Disassembly - (cont.)
• Repair
• Assembly
• Assembly (CONT)
• Assembly - (cont.)
• GREASE CONTROL VALVE - REPAIR/ADJUST
• GREASE CONTROL VALVE - REPAIR/ADJUST
• Repair
• IMAGE
• Adjustment
• IMAGE
• AIR COMPRESSOR ASSEMBLY - TEST
• STARTER - REPAIR
• IMAGE
• Repair
• Assembly
• Test
• ALTERNATOR - REPAIR
• Disassembly
• IMAGE
• Repair
• Repair (cont.)
• MAIN ALTERNATOR FRAME
• Assembly
• Assembly (CONT)
• AIR COMPRESSOR - REPAIR
• IMAGE
• Disassembly - (cont.)
• IMAGE
• Disassembly - (cont.)
• IMAGE
• Repair
• Assembly
• Assembly - (cont.)
• IMAGE
• Assembly - (cont.)
• IMAGE
• HEAD- REPLACE/REPAIR
• Removal
• Disassembly
• IMAGE
• Repair
• IMAGE
• Installation
• CENTRIFUGAL UNLOADED - REPLACE
• Installation
• AIR REGULATOR - REPAIR
• Assembly
• LOW PRESSURE PUMP
• Disassembly - (cont.)
• Disassembly - (cont.)
• IMAGE
• Disassembly - (cont.)
• Disassembly - (cont.)
• Repair
• Assembly
• Assembly
• IMAGE
• Assembly - (cont.)
• Assembly - (cont.)
• Assembly - (cont.)
• HIGH PRESSURE PUMP - REPAIR
• HIGH PRESSURE PUMP - REPAIR
• Disassembly - (cont.)
• IMAGE
• Disassembly - (cont.)
• Disassembly - (cont.)
• Disassembly - (cont.)
• IMAGE
• Repair
• IMAGE
• Assembly - (cont.)
• IMAGE
• Assembly - (cont.)
• IMAGE
• Assembly- (cont.)
• IMAGE
• Assembly - (cont.)
• LUBE TANK- REPAIR
• CONTROL BOX- REPAIR
• Assembly
• FRAME AND SKID ASSEMBLY - INSPECT/REPAIR
• IMAGE
• POWER CLUSTER - REPLACE/REPAIR
• Removal
• Disassembly
• IMAGE
• Installation
• AXLE ASSEMBLY - REPLACE
• Installation
• IMAGE
• FRAME ASSEMBLY - REPLACE
• CHAPTER 6 Section I. PMCS AND TROUBLESHOOTING PROCEDURES
• Repair
• Replace
• Repair
• FRAME ASSEMBLY - REPAIR
• APPENDIX A REFERENCES
• MANUALS
• APPENDIX B MAINTENANCE ALLOCATION CHART
• EXPLANATION OF COLUMNS IN THE MAC, Section II
• EXPLANATION OF COLUMNS IN TOOL AND TEST EQUIPMENT REQUIREMENTS, Section III
• Section II. MAINTENANCE ALLOCATION CHART
• Section II. MAINTENANCE ALLOCATION CHART (CONT)
• Section II. MAINTENANCE ALLOCATION CHART (CONT)
• Section III. TOOL AND TEST EQUIPMENT REQUIREMENTS
• Section IV. REMARKS
• APPENDIX C COMPONENTS OF END ITEM AND BASIC ISSUE ITEMS LISTS
• Section II. COMPONENTS OF END ITEM
• Section II. COMPONENTS OF END ITEM
• Section II. COMPONENTS OF END ITEM
• Section III. BASIC ISSUE ITEMS
• APPENDIX D ADDITIONAL AUTHORIZATION LIST
• APPENDIX E EXPENDABLE AND DURABLE SUPPLIES LIST
• Section I. INTRODUCTION
• Section I. INTRODUCTION (CONT)
• APPENDIX F ILLUSTRATED LIST OF MANUFACTURED ITEMS
• Figure F-2 Plate Anchor, Shipping
• APPENDIX G TORQUE TABLE
• INDEX
• INDEX (CONT)
• INDEX (CONT)
• INDEX (CONT)
• INDEX (CONT)
• INDEX (CONT)
• INDEX (CONT)
• The Metric System and Equivalents
• TM-5-4930-233-14
• BLANK PAGE
• By Order of the Secretaries of the Army and Navy (Including the Marine Corps):
• RECOMMENDED CHANGE TO EQUIPMENT TECHNICAL PUBLICATION

Privacy Statement - Press Release - Copyright Information. - Contact Us